Vari Lite VL2500 Spot Luminaire Manuel de service Page 111
- Page / 142
- Table des matières
- DEPANNAGE
- MARQUE LIVRES
Noté. / 5. Basé sur avis des utilisateurs
ILLUSTRATED PARTS BREAKDOWN: ENCLOSURE
3
02.9676.0020 B 29-May-2009 93
Pan Motor Assembly (continued)
Figure 3-31: Pan Motor Assembly
0.875"
Note: Vari-Lite recommends that this assembly be replaced as a complete assembly. Although you can replace only the motor, the pulley (Item 2) is bonded
to the motor shaft during assembly and cannot be removed intact. If you order a replacement motor (Item 4), also order the pulley (Item 2). Contact Vari-Lite
Customer Service for installation information.
2
Step 1. Apply one drop of Loctite 603 to motor shaft.
Step 2. Install drive pulley on motor shaft using twisting
motion to insure coverage of shaft with loctite.
Step 3. Do not allow Loctite to drip into motor bearing.
Step 4. Set pulley height as shown above.
Step 5. Apply Loctite 242 to pulley set screws. Insure set
screws are aligned and tightened on flat sides of
motor shaft.
Detail A
Drive Pulley Detail & Installation
See Detail A
2a
2c (x2)
2b
Pressure-Sensitive Adhesive
1
2
3
4
5 (x4)
6 (x4)
7 (x2)
8 (x2)
Connector oriented
on this side
- Compliance Notice 4
- Safety Notice 4
- FOREWORD 5
- Sicherheitshinweise 7
- Notes de sécurité 9
- POT LUMINAIRE SERVICE MANUAL 10
- Aviso sobre Seguridad 11
- SAFETY NOTICE (JAPANESE) 13
- Table of Contents 15
- TABLE OF CONTENTS 17
- Introduction 19
- Customer Service 20
- CHAPTER 1 21
- Description 21
- Features 22
- Major Components 23
- Menu Display 24
- Menu Controls 24
- Head Components 25
- Yoke Components 26
- Enclosure Components 27
- Principles of Operation 28
- CHAPTER 2 29
- Maintenance 29
- Testing Software 30
- Troubleshooting 31
- Troubleshooting Guide 32
- AINTENANCE : TROUBLESHOOTING 33
- Maintenance Procedures 34
- Lamp Replacement (continued) 35
- 02.9676.0020 B 29-May-2009 19 37
- Gobo/Color 37
- Filter Wheel 37
- Gobo/Color Filter 37
- Carrier Slot 37
- Strobe Bulkhead Replacement 38
- Front Assembly Removal 39
- Rotating Gobo Sensor PCB 41
- 02.9676.0020 B 29-May-2009 25 43
- Standoff on Edge Motor Shaft 44
- 4-40 SS KEPS Nut 44
- Lens Barrel 44
- Assembly 44
- Yoke Assembly 48
- 02.9676.0020 B 29-May-2009 31 49
- Yoke Leg Cover 49
- Ignitor PCB Replacement 50
- Enclosure Assembly 52
- 02.9676.0020 B 29-May-2009 35 53
- 02.9676.0020 B 29-May-2009 37 55
- 02.9676.0020 B 29-May-2009 39 57
- Pan Encoder Replacement 58
- 02.9676.0020 B 29-May-2009 41 59
- CHAPTER 3 61
- Drawing Tree 62
- Drawing Tree (continued) 63
- Top Assembly 64
- 02.9676.0020 B 29-May-2009 47 65
- 15 13 12 14 11 65
- VL2500 Spot Luminaire 66
- 02.9676.0020 B 29-May-2009 49 67
- VL2500 Generic Luminaire 68
- 02.9676.0020 B 29-May-2009 51 69
- Front Assembly 70
- Figure 3-4: Front Assembly 71
- Lens Barrel Assembly 72
- 02.9676.0020 B 29-May-2009 55 73
- Sub-Barrel Group 2 Assembly 74
- Motor Zoom Optics Assembly 75
- Rotating Gobo Wheel Assembly 76
- Top Cover Assembly 77
- Bottom Cover Assembly 78
- Reflector Assembly 79
- Back Cap Assembly 80
- Back Cap Assembly (continued) 81
- Fan Assembly 82
- Fan Assembly (continued) 83
- Refer to Figure 3-14 84
- 02.9676.0020 B 29-May-2009 67 85
- Crossfade Color Assembly 86
- Iris/Gobo Motor Assembly 88
- Color Motor Assembly 89
- Gobo Wheel Assembly 90
- Color Filter Wheel Assembly 91
- Strobe Assembly 92
- Strobe Assembly (continued) 93
- UV / IR Window Assembly 94
- Yoke Assembly (continued) 96
- Tilt Motor Assembly 97
- 80 29-May-2009 02.9676.0020 B 98
- Yoke Fan Assembly 99
- Enclosure 101
- No. Item Qty. UM. Description 102
- 02.9676.0020 B 29-May-2009 87 105
- Connector Panel Assembly 106
- DMX Input PCB Assembly 107
- Refer to Figure 3-28 108
- Pan Tube Assembly 109
- Pan Motor Assembly 110
- 02.9676.0020 B 29-May-2009 93 111
- Upper Enclosure Fan Assembly 112
- Refer to Figure 3-33 113
- Ground Strap Cable Assembly 115
- Refer to Figure 3-49 116
- Refer to Figure 3-50 117
- Refer to Figure 3-52 119
- Refer to Figure 3-53 120
- Refer to Figure 3-54 121
- Refer to Figure 3-55 122
- Refer to Figure 3-56 124
- Strobe 1 Cable Assembly 126
- Refer to Figure 3-58 127
- Refer to Figure 3-59 128
- Refer to Figure 3-60 129
- Refer to Figure 3-61 131
- Refer to Figure 3-62 132
- Data I/O Link Cable Assembly 134
- Display Cable Assembly 135
- Refer to Figure 3-65 136
- Refer to Figure 3-66 137
- DC Output Cable Assembly 138
- APPENDIX A 139
- ❋ Fax 1.214.647.8038 142
Produits connexes et manuels pour Lumières des projecteurs Vari Lite VL2500 Spot Luminaire
(84 pages)© 2020, manymanuals.fr. Tous droits réservés | 0.040 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Commentaires sur ces manuels